6-speed transmission DSG 02E car Skoda Superb 2

General information about the 6-speed DSG transmission «02E»
6-speed DSG 02E is available on both FWD and AWD models ( see specs ). The DSG identification code is on the vehicle data sticker (see Introduction). The DSG itself is also marked with its identification code (HLH in...

Features of repair work, troubleshooting
1. If the DSG covers are removed, or if there is no working fluid in the DSG, do not start the engine or tow the vehicle with the front wheels off the ground. 2. Thoroughly clean the area around the bolts and the...

Checking and replacing the working fluid and filter, replacing the flanged shaft seals
1. Checking the fluid level of the 6-speed DSG is done when replacing it ( see Section 21 of Chapter 1 ). 2. 6-speed DSG fluid and filter change is required every 60,000 km. 3. The filter should be replaced: every...

Works with the selector mechanism
1. Details of the installation of the components of the selector mechanism are indicated on Ref. illustrations. The following procedures are performed in the same way as on models with a 7-speed DSG ( see Section 7 ):...

Removal and installation of some parts outside the DSG
1. The location of serviceable components on the DSG is shown in Ref. illustrations. Filter replacement is described in Chapter 1 . 14.1 Location of serviceable components outside the DSG 1 Oil pan 2 Pan 1 bolts, 5...

Removal and installation of double clutch
1. Clutch assemblies require special handling as All components are balanced during production. If the parts rotate relative to each other during assembly, the balance is disturbed, which reduces the life of the clutch...

Removal and installation of DSG
Note: Description is based on 2.0L AWD models. The DSG is removed downwards with the corner gear, separate from the engine. 1. Set the selector lever to position "R". 2. Disconnect the negative cable from the battery....